By MaryBeth Matzek
MAA Editor

The Wisconsin Department of Natural Resources has approved a permit allowing a Kewaunee County farmer to use manure irrigation on his fields.
Pagel’s Ponderosa Dairy asked the DNR if the dairy could use two center pivot systems to spray manure on selected fields. The announcement comes less than a month after a U.S. Department of Agriculture researcher shared results of a study showing the chance of getting sick from manure being irrigated is quite low – even when someone is in close proximity.
As part of a study paid for by the state Department of Natural Resources, USDA microbiologist and researcher Mark Borchardt and other researchers went to three farms in different parts of the state and measured the amount of microbes in the air at various distance points from an active manure irrigator.
 “Going out and gathering empirical data hadn’t been done before,” Borchardt said. “We weren’t just trying to guess something in a lab or wind tunnel.”
The study’s preliminary findings show the risk of contracting an illness from manure irrigation rank between the two benchmarks associated with water illness: Safe drinking water, which defined as one acute gastrointestinal illness per 10,000 people for an entire year, and a safe swimming area, which is defined as 32 people contracting an acute gastrointestinal illness from the water on a single day. Illness symptoms include severe vomiting, diarrhea and nausea.
 “The question for policymakers is now decide if that’s an acceptable risk,” Borchardt said. “One level is very, very low risk while the other one is higher. We went with those two benchmarks since those are the standard ones out there.”
John Pagel, owner of Pagel’s Ponderosa Dairy, referenced the study when he discussed his reasons for wanting to pursue manure irrigation. He sought permission from the DNR to use an irrigation system to irrigate some of the 67 million gallons of manure produced annually on his dairies.
The effluent run through the irrigator would be what’s left over after the manure is run through two separate cleaning systems, including a biodigester and a nutrient recovery system that removes nitrogen and phosphorus, Pagel said.
 “It will be mostly water coming out with some potassium,” he said. “A chemical analysis of the digested manure showed no signs of the common pathogens like E.coli. Most of those pathogens are killed through the biodigesting process.”
The permit calls for the dairy to visually monitor fields receiving manure irrigation applications hourly or more frequently and to document the monitoring results in a record sheet that will be submitted annually to the department, along with Pagel’s Nutrient Management Plan update.
Pagel and other irrigation supporters said the practice, which uses pipelines and irrigation systems, allows for precise application and reduces runoff because the liquid can be applied while crops are in the field. Groundwater contamination would be prevented, too, because the crops would take up the nutrients before it moves deep into the soil. 
“Right now, we can only spread two times a year. With this, we can apply it to growing crops,” he said. “It’s better for the plant and safer for the ground since smaller amounts are being applied at one time.”
Pagel plans to also use large drop nozzles, cutting down on possible drift.
The practice is also less expensive than the traditional method of trucking the manure to the field and then applying it with a manure spreader. Also, there would be less wear and tear on the roads. 

Currently, there are 14 concentrated animal feeding operations for CAFOs in Wisconsin that use manure irrigation.
In Borchardt’s study, researchers looked for the presence of microbes commonly found in manure, including E.coli, salmonella, cryptosporidium and giardia. Borchardt said the microbes do not live long in the air since heat and sunlight kill them.
The research was arduous and challenging, Borchardt said. Researchers measured the amount of microbes in the air at various lengths ranging from 100 feet to 750 feet downwind from both a traveling gun irrigator and a center pivot irrigator at three working farms.
“What sets what we did apart is that we did our research in real-life conditions and in real weather,” he said.
Next, researchers took a statistical approach to predict what would happen downwind in different weather and wind conditions. Finally, they did a risk assessment looking at how much of a certain microbe could be ingested before someone became sick.
“We were then able to estimate risk based on distance and weather. There’s no disputing our findings,” Borchardt said. “Risk levels go down with distance and the wind speed plays a role.”
Borchardt knows the study has its detractors, some of whom were at a meeting March 15 in Luxemburg where he presented an overview of his team’s work.
“People say we didn’t look at odor, we didn’t look at runoff or drinking water, but we needed to have a defined area of risk for our study and went with microbes in the air,” he said. “We couldn’t look at everything and this was a good starting point.”
When asked at the March 15th meeting to share his personal feelings about the potential for problems, Borchardt, who usually gathered the readings at the location closest to the manure irrigator, said,  “I’m fine with the risk level.”
 


Comments


Your comment will be posted after it is approved.


Leave a Reply